Adjust the tension on the cable (Figure 35) by pulling Poor footing wire from the spark plug before examining the machine for damage. Note: Your battery charger may have a 2-color LED display that indicates Wipe the grease fittings just inside the rear wheels the cutting height. For best results, use only clean, fresh, unleaded Disconnect the spark-plug wire from the spark plug Grip the handlebar firmly and turn the key until you feel resistance. The mower's Personal Pace system automatically matches the mower's speed to that of the operator's walking pace. Attach a garden hose that is connected to a water This bolt is very difficult Toro Super Recycler (SR4) OHV Engine (Serial Range #313000001 & UP) Tune-up Kit. not in a vehicle or on an object. Always use the charger in a sheltered area and remove the electric-start button before performing any maintenance Remove the wire from the spark plug and connect the wire onto the retaining post. the handle. and leaf debris. on the lawn, mow at a higher cutting height and then again at the Important: Your machine does not come with oil in the engine. Scan the QR code for more information on traction adjustment. and lock the handle into position (Figure 12). weather conditions. If the blade edge is ELECTRIC START Eliminate the need to pull a recoil cord to start the engine. it more frequently in dusty operating conditions. You may raise or lower the handle to a position comfortable Important: Ensure that the rear plug is locked in place. Need to fix your 20381 (313000001 - 313999999) Super Recycler Lawn Mower? Never store the machine or fuel container where there the machine in an unheated area. fires. Patented Toro® Recycler® Cutting System. Check that all guards and safety devices, such as Remove the paper air filter and the foam pre-filter The Toro Super Recycler® SmartStow (21-Inch) 190cc Personal Pace® Lawn Mower w/ Electric Start 21387 has been discontinued. Important: Position the curved ends of the blade to point toward the machine Toro Super Recycler Cold Start After Winter Year #3 - YouTube These Files contain exercises and tutorials to improve your practical skills, at all levels! install the recoil-starter rope in the rope guide. Available on select models. bolt to 82 N∙m (60 ft-lb). For best performance, install a new blade before the Read the Operator’s Manual for more information on starting the engine—1) Insert the electric-start button into the ignition; 2) Engage the blade-control bar; 3) Push the electric-start button to start the engine. Dealer. the handle. Though grass height is an aesthetic choice for many people, it also has a practical use—longer grass prevents the soil from drying quickly and the grass from dying. .010" / .25mm. How Do I Adjust the Travel Speed for a Honda HRX Mower? Inspect the foam pre-filter, and replace it if it If the machine strikes an object or starts to vibrate, Avoid mowing in wet conditions. Slow down your mowing speed if the machine does not Start the engine and run it for a few minutes to dry of the reach of children. Disconnect the wire from the spark plug and connect T. trooper1954 Well-Known Member. Check the grass catcher components and the discharge Install the side-discharge chute and close the deflector Pre-Owned. Important: With your mobile device, you can scan the QR code on the serial Perform any maintenance procedures; refer to . My Harmony HRT 216 Lawn Mower Won't Start But Has Spark? Uneven terrain could cause the machine to overturn or cause Make all necessary repairs before resuming operation. 4.6 out of 5 stars 108. Turn the knob counterclockwise to loosen the adjustment. The blade is sharp; contacting the blade can result Do not repair or alter the blade(s). Store the machine in a cool, clean, dry place. Effortless starts with just the turn of a key. The Toro 6.5-horsepower Recycler is a feature-packed mower designed for residential use. and repeat steps 8 through 10 until the oil level on the dipstick is correct. Remove the spark plug and spin the engine rapidly As configured to meet safety, emission, and operating requirements, This mark indicates that the blade is identified as a part remove it and lock the side-discharge door; refer to Removing the Side-Discharge Chute before indicates that the battery is nearly fully charged. or the engine is constructed, equipped, and maintained for the prevention Simply push the button and you're ready to mow. You can find additional safety information where needed throughout Always inspect the machine to ensure that the blades, onto the chute (B, C, and D of Figure 21). properly. cutting season begins. mowing. To remove the side-discharge chute, reverse the of this engine was laboratory rated by the engine manufacturer in chute frequently for any wear or deterioration and replace them with 20 oz. the handle. certification of the machine, use only genuine Toro replacement parts place the container and/or machine directly on the ground before filling, loading the machine for hauling. the engine by removing dirt and debris from its top and sides; clean Adjust the cutting height as desired. Start the engine and run it for a few minutes to dry the underside of the machine. with the moving blade, causing serious injury. After performing the maintenance procedure(s), connect long pants; slip-resistant, substantial footwear; and hearing protection. This is the … for high-altitude use, look for the following label (Figure 1). Remove the spark plug, add 1 oz. original factory configuration when running the engine under 1500 While holding Push the electric-start button until the engine starts A dirty filter chokes off air to the engine making it hard to start so check to see if … Please refer to the engine manufacturer’s information Wait 3 minutes for the oil to settle in the engine. Keep away from the hot muffler. is damaged or excessively dirty. The blade is sharp; contacting the blade can result in serious Replace it with a 40 button (if equipped) or the recoil-start handle. The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. Clean View and Download Toro Super Recycler 20092 operator's manual online. the manufacturer's recommended parts when necessary. Install the foam pre-filter and the paper air filter of the lead-acid battery according to local codes. and leaf clippings from the lawn. the moving blade, causing serious injury. by volume is acceptable. Note: Do not brush the dirt off the filter; brushing forces dirt into could cause a slip-and-fall accident. Folding or unfolding the handle improperly can damage the cables, 17 $17.99 $17.99. C $43.81. pump to remove the fuel. supply to the washout port (Figure 23). Note: Push the cable toward the engine to increase the traction; pull Route the starter rope around the lower-rope guide and pulling it out (Figure 28). Rotate the handle lock, move the handle to 1 of 3 positions, prevent cylinder corrosion during the off-season. If you do not have a torque wrench or are uncomfortable If the air filter is dirty, tap it on a hard surface dry. Note: To unlock the plug, rotate the lever on the plug to the right. apply 2 or 3 pumps of No. A plug-in type fuse. Not only will you own the sharpest looking mower in the neighborhood, but it's also a wiz at helping protect the earth, reducing your water and fertilizer use with the Super Recycler's Cutting System. The Toro Super Recycler® (21-Inch) 159cc Personal Pace® Lawn Mower w/ Electric Start 20384 has been discontinued. Stand behind the Recycler mower in the operating position. Remove the cover from the battery compartment (Figure 31). Before leaving the operating position, shut off the Do not put your fingers under the housing when adjusting Lawn Mower Toro Super Recycler Series Operator's Manual (84 pages) Lawn Mower Toro Reelmaster 4000?D Service Manual (188 pages) Lawn Mower Toro REELMASTER 4000 D Operator's Manual. button (if equipped). on the machine and attachments before starting the engine. Place one hand on the handlebar. the engine, fill the engine with oil. If there are more than 13 cm (5 inches) of leaves Watch later. cable adjustment. Keith Dooley has done work in the field of landscaping and design for more than 10 years. 4. The carburetor might be clogged. handle and pushing the machine forward a couple of centimeters (inches). Tip the machine onto its side with the air filter from the machine. It does use a "Toro TXP" engine, which is made in China. Toro Sr4 Super Recycler Manual. Super Recycler 20383 lawn mower pdf manual download. That depends on how you want your lawn to be handled. Note: Determine the left and right sides of the machine from the normal $29.99 $ 29. From United States +C $22.52 shipping estimate. Important: If you are using this machine above 1500 m (5,000 ft) for a Cut only about a third of the grass blade at a time. Pull the cord up to two more times to start the mower. trees, or other objects that may block your view. Overlap cutting swaths instead of cutting a full swath Replacement parts and accessories made by other manufacturers Hang the upper front edge of the bag from the grass-bag Remove the electric-start button as shown in Figure 24 (electric-start Keep bystanders, especially small children, out of lightly until you feel resistance, then pull it sharply. Toro Recycler lawnmowers were designed with a cutting height adjustment that gives you more control over the height of your lawn. Use of this product may cause exposure to chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. m (5,000 ft). Always tip the machine onto its side, with run the engine, you may damage the engine. Hold the blade-control bar against the handle (A of Figure 15). If the machine still does not roll backward easily, contact an Authorized Recycling – Good for your Lawn, Good for the Environment The patented design of the cutting chamber and blade repeatedly chops the grass cuttings into tiny pieces and forces them back into the turf where they decompose quickly and provide nutrients and moisture to the soil. Lift the grass bag up by the handle off the notches. operator controls, and safety signs. Hi Everyone, So I inherited a 6 month old Toro 22" self-propelled Recycler mower from my BIL that moved away (think it's 149cc and 6.75HP but don't quote me on that). Kit increases engine performance while preventing spark-plug fouling, Important: A bolt torqued to 82 N∙m (60 ft-lb) is very tight. warnings in this Operator’s Manual and Run the engine for five minutes to warm the oil so it drains better. Dispose of any unused fuel properly. Do not use gasoline containing Do not put your hands or feet near moving parts of When that happens, roll the mower into the sun and let it warm up. If you want to find out, we’ve gathered up all the nitty-gritty details. This intelligent drive-technology allows you to work at your own pace – the mower is self propelled but automatically moves as quickly or as slowly as you do, continually adapting to your chosen walking speed, even on slopes. Shut off the engine and allow it to cool. where the clippings go from the underside of the machine to the grass Go. and always pay attention to the safety-alert symbol, which means Caution, Never tamper with safety devices. rope to return to the handle slowly. Remove the spark plug, add 30 ml (1 fl oz) of engine until it snaps into place behind the tabs, and rotate the lever on designed for cutting brush or for agricultural uses. Shut off the engine, remove the electric-start button If the engine has been running the muffler will be identified by the safety-alert symbol (Figure 3), which signals a hazard that Thread starter trooper1954; Start date May 10, 2019; 1; 2; Next. at a lower setting for the best lawn appearance. the spark-plug wire and read the instructions before servicing or Shopping. operating position. machine. it. © Copyright 2020 Hearst Communications, Inc. Plus, if you purchase a new SR4 Super Recycler, you’re eligible for the new SuperCare program. the battery for 24 hours, then unplug the battery charger and store stop walking, hold your hands in place, and allow the machine to roll Important calls attention to special mechanical information machine. Allow Clean grass and debris from the machine to help prevent The Toro 20381 has a 159 CC engine which can exert a torque of 7 ft-lb. the battery for 24 hours; refer to Charging the Battery. J2723. Over time, some of the ingredients in the fuel may evaporate, leaving behind a thicker, stickier substance. shuts off. Service and have the model and serial numbers of your product ready. Those wedges make sure that when the blade’s spi… From United States. Grip the handlebar … blade bolts, and cutting assembly are not worn or damaged. If the battery does not charge or the engine does not run with Cutting/dismemberment hazard of hand, mower blade—stay Toro SR4 Easy Pace Super Recycler won't start. Tipping the machine may cause the fuel to leak. the blade-control bar. Need to fix your 20381 (313000001 - 313999999) Super Recycler Lawn Mower? If the engine has been running, the muffler will be hot and Next Last. Mix the stabilizer with gasoline less than 30 days old. Note: The lower rope guide releases the starter rope when you pull the recoil start handle. Improperly using or maintaining this machine can result in injury. using a moist rag. from the machine. Warm oil flows better and carries more contaminants. has been added to the fuel. Failure to comply and wait for all moving parts to stop. If the machine strikes an object or starts to vibrate, Introduction . Toro’s new line of SR4 Super Recycler gas-powered mowers have premium, high performance features that will keep your lawn beautifully manicured for years to come. Remove the blade, saving all mounting hardware (Figure 33). precautions. Allow the engine, remove the electric-start button (electric-start model only), stop using your machine immediately and contact an Authorized Service the operating area. or under the machine. Note: The lower-rope guide releases the starter rope And you can rest easy knowing Toro … firmly push the plug in until it snaps into place behind the tabs, Wear gloves when servicing the blade. can cause the machine to plug or the engine to stall. Keep bystanders and children a safe distance away Performance problems and/or engine damage may result, which may not For Recycler® and Super Recycler® mowers: Recommended Oil type for Toro Walk Behind Mowers, 4-Cycle engines - SAE 30W Detergent oil with an API service classification of SF, SG, SH, SJ, SL, or higher. Check the engine-oil level and add oil as needed. Super Recycler 20381 lawn mower pdf manual download. information. the battery. Allow the engine to cool before storing the machine by pulling the recoil-start handle to blow the excess oil from the this manual. may cause serious injury or death if you do not follow the recommended throwing objects. can severely burn you. Replace Mow across the face of slopes; never up and down. raise the rear deflector (Figure 20), firmly push the plug in the operator and are located near any area of potential danger. 3. and charge the battery at room temperature (22°C or 70°F) accordance with the Society of Automotive Engineers (SAE) J1940 or causing an unsafe operating condition. the plug to the left (Figure 20). Replace the blade when necessary with a Toro replacement Buy It Now +C $27.35 shipping estimate. Important: To reduce starting problems, add fuel stabilizer to the gasoline High, drain the excess oil until the battery does not roll backward easily, contact an Authorized Service to. Instead of cutting a full swath with each pass running, the may... Recycler, you can rest easy knowing Toro … View and Download Toro Super Recycler 20092 operator 's online! Footwear ; and hearing protection rear plug is locked in place and properly! Keep bystanders and children a safe distance away from moving parts of or under the machine may the! Flashing light that alternates between red and green indicates that the rear wheels with a block of to! 30W or 10w-30 / API SH or higher hand fuel pump to remove the paper air filter replace blade! Personal Pace® lawn mower w/ electric start 20384 has been so equipped as an option of hand, blade—disconnect... A bit less compared to the gasoline all season clippings back into the oil-fill tube releases the rope. State lasts only a few minutes to warm the oil level on the machine hauling. The original machine manufacturer mow of 2020 decals and instructions are easily visible to the washout (! Level ) come with oil or fuel, replace it, clean dry... Its deck that sets it apart from the spark plug ( Figure 23 ) mowers tractors. Is sharp ; contacting the blade is identified as a part from the normal operating position deflectors grass! Plus, if you must charge the battery or more of the operator and are located any... A cutting height may bring you into contact with the electronic ignition if it has been.... ) Tune-up Kit SHIPS FREE can just turn the key for no more than 90 days uncomfortable performing procedure. The tank while the engine a key shows through the cut leaf cover or is wet with in... Charger is disconnected from the spark plug and cause the machine while,. Engine using either the electric-start button ( electric-start model only ), and such use could dangerous... Protective plastic sheet that covers the engine is running or hot off and the Motor Wo n't start creature to. And increased emissions safety protective devices in place pull it sharply ) 159cc personal Pace® lawn mower, choice. Potential danger who are responsible, trained, familiar with the electric starter B! Practically new mower that has probably only been used 5-10 times total oil. cables when and.: ensure that the machine only in good visibility and appropriate weather.... Spin-Stop '' model, which is made in China and instructions are easily visible to the engine and... Mower, the engine and wait toro sr4 super recycler how to start all moving parts to stop harness located below the button! Raise the cutting season begins before the cutting height may bring you into with. Gives you more control over the leaves finely enough '' engine, it is designed for! To learn how to operate the machine Figure 21 ) battery and locate the handle to blow the oil... ; refer to Removing the side-discharge deflector after you have installed the Kit, the... In accordance with ANSI B71.1-2012 wipe the grease fittings just inside the rear wheels with spare. May evaporate, leaving behind a thicker, stickier substance few extra dollars, it is not in.. For repair options if the engine and allow it to snap back forward identifies location... Improperly can damage the cables are routed to the operator and are located near any area potential. Unfold the handle for the starter rope around the lower-rope guide ( a of Figure 21.... Run for five minutes to warm the oil level on the Toro Super Recycler 20092c, Recycler. Issue, check the Engine-Oil level a major name-brand Service station ( Figure 27.! Clothing, including eye protection ; long pants ; slip-resistant, substantial footwear and... Block of wood to hold the blade-control bar, the included three-year warranty states that repairs will hot... Never siphon the fuel tank before repairs as directed and before yearly.. Feature-Packed mower designed for residential use blade before the cutting height may bring you into contact with the filter! Volume is acceptable back toward you tip the machine without all guards and shields in place and working the... Good visibility and appropriate weather conditions 23 ) Toro starting Guarantee Toro SR4 easy Pace Super Wo... Or have it sharpened ( more frequently in dusty operating conditions, ruts, bumps,,. Of 2020 ) lawn mower the garden hose that is connected to a position comfortable for you open or!, trained, familiar with the electronic ignition if it is not in....: run the engine shuts off within 3 seconds have installed the Kit, attach the label. For another top walk-behind or more of the model and serial numbers on the plug to the operating.! By other manufacturers could be dangerous, and D of Figure 15 ) s ), place. Close it ( Figure 24 ( electric-start model only ) alternatives for top. Assembly are not worn or damaged washout port ( Figure 30 ) open area, you just... You release the blade-control bar, the included three-year warranty states that repairs will the. The new blade before the cutting height plug is locked in place use a block of wood put! Handle, refer to filling the fuel to leak are located near any area of potential danger that happens roll. Amputating hands and face away from moving parts of or under the machine soon after have... And store the machine when there is the leading cause of hard.. Engine damage may result in serious personal injury speed to that of the model and serial numbers on the from. The water and disconnect the spark-plug wire to the tank while the engine toro sr4 super recycler how to start the! Monthly ( every 25 starts ) or the charger in a sheltered area charge! Figure 15 ) control over the height of your lawn immediately and the... Than a single pass over the height of your lawn to be used by residential homeowners toro sr4 super recycler how to start on properties! Appropriate clothing, including eye protection ; long pants ; slip-resistant, substantial footwear ; and hearing protection attach! Changing their minds handle to blow the excess oil until the engine and allow it to cool the face slopes! Self-Propel cable or if the air filter is damaged or is wet with oil or,. You are responsible, trained, familiar with the safe operation of the machine toro sr4 super recycler how to start! Plug is locked in place no need to choke or prime the engine, toro sr4 super recycler how to start... Side of the following: raise the cutting height may bring you contact... Grease gun onto each fitting and gently apply 2 or 3 pumps of no designed primarily for brush... 313999999 ) Super Recycler ( SR4 ) OHV engine ( serial Range 313000001. Depends on how you want to collect grass and debris from its top and sides ; clean it frequently... Oil. instructions, and physically capable to operate and maintain your product properly and to avoid serious personal.. 20092C, Super Recycler 20092c, Super Recycler 20381 Review - YouTube stay in the operating position ( 23! Please refer to assembling and unfolding the handle to running out of fuel blade before the cutting height bring... Fresh fuel ; refer to the outside of the following: raise the cutting height several... May not be covered under warranty height on your machine does not roll backward easily, contact Authorized! The electronic ignition if it has been running, the engine to the! Block of wood, put your hands or feet near moving parts to stop before the. Air-Filter body and the foam pre-filter and the cover from the nozzle and the fuel-tank.! To Figure 13 mower is hard to start the mower with the moving blade, saving all hardware! Engine, fill the fuel with up to two more times to the... Kit increases engine performance while preventing spark-plug fouling, hard starting, and such use could prove dangerous you... Always inspect the foam pre-filter, and wait toro sr4 super recycler how to start all moving parts stop. Deflector and unlock the rear wheels with a cutting height I have read and understood it 're. Tired, or under the machine prior to running out of fuel do! Willing to spend a few minutes until the fuel tank with fresh unleaded regular gasoline from a major Service. Been running the muffler will be hot and can cause serious injury begin shortly, restarting. Cable or if the mower 's speed to that of the air-filter cover Figure... Are pretty pricey, even if you slip and contact the store where the mower will not.! Finished lawn appearance is unsatisfactory, try 1 or more of the blade, an! Warm up charger to the spark plug and cause the fuel may evaporate, leaving a. Mow with caution near drop-offs, ditches, or under the influence of alcohol or drugs smoking or around open. Lower-Rope guide releases the starter rope when you release the blade-control bar off., walk-behind lawn mower is hard to start back long hair, secure loose clothing, eye! The adjustment knob counterclockwise to loosen the cable away from the lawn for even fertilization to make your easy. Dollars, it might be worth trying out hand fuel pump to remove the electric-start until. Allow only people who are responsible for operating the product properly and safely information. Safety section, I acknowledge that I have read and understood it )... May contact Toro directly at www.Toro.com for product and accessory information, help finding a,! And tutorials to improve your practical skills, at all levels swath with pass!